SURFACE MAINTENANCE REPAIRER (T32)
Army National Guard Units
Summary This National Guard position is for a SURFACE MAINTENANCE REPAIRER (T32), Position Description Number D1193000 and is part of the FL SMO, National Guard. Responsibilities As a SURFACE MAINTENANCE REPAIRER (T32), WG-5801-8, you will perform limited diagnosis, routine repairs and maintenance on heavy-duty mobile equipment, combat, tactical and automotive vehicles. Assists higher graded mechanics in the repair and/or overhaul of major systems to include internal combustion engines, turbine engines, automatic and non-automatic transmissions, heavy duty drive line systems, and hydraulic utility systems and controls. Make routine repairs that can be accomplished by removing, adjusting, or replacing defective or worn parts and components. Perform work in accordance with technical manuals, lubrication orders, maintenance bulletins, regulations or management policies. Perform limited diagnoses to determine the cause of mechanical failures by means of visual and auditory checks and/or uses basic test equipment such as compression testers, voltmeters, ohmmeters and pressure gauges. Determine when parts should be cleaned, adjusted or replaced with standard parts to complete work orders. PHYSICAL EFFORT: Work is performed in tiring or uncomfortable positions for long periods. There is frequent standing, bending, reaching, stretching, climbing, and crouching; or working on top of, under, and in tight compartments or cramped or awkward positions. Performs strenuous work while standing, lying, or sitting. Frequently lifts and carries items, unassisted, weighing up to 40 pounds; and often exerts similar effort in pushing, pulling, and positioning parts, assemblies, and equipment. Frequently lifts and moves heavier items with the assistance of other workers or with lifting devices such as jacks, hoists, and cranes. May be required to work from ladders or work platforms at varying heights. WORKING CONDITIONS: Work is performed both inside and outside. When inside, the incumbent is frequently exposed to drafts, changing temperatures, and noise which is difficult to talk above. When outside, the incumbent is exposed to bad weather, in mud or snow, and in wet or icy areas. The incumbent is frequently exposed to irritations or discomfort from dust, heat, fumes, and hard damp floors or ground. Typically works on parts and systems, which are dirty, oily, or greasy. Frequently exposed to the possibility of cuts, burns, bruises, and sprains while repairing, positioning, and moving equipment. Often exposed to the possibility of falls while repairing, positioning, and moving equipment; and skin irritations from acid, fluids, and lubricants. Uses safety equipment such as protective ear devices, hard hats, hard-toe shoes, respirators, and protective clothing, which may be uncomfortable to wear or use and may be worn or used for long periods. Requirements Conditions of Employment Qualifications AREA OF CONSIDERATION: This position is in the Excepted Federal Civil Service “under the authority of 32 U.S.C. 709” and is open to Category 1 & 3 Only. Category 1: All permanent/indefinite (T32 and T5) technicians employed by the agency WITH dual FL National Guard military membership; Category 3: All current military members of the Florida National Guard. First consideration will be given to Category 1. PCS: Permanent Change of Station (PCS) costs, Recruitment or Relocation Incentive MAY be authorized. Authorization for payment of PCS expenses, Recruitment or Relocation Incentive will be granted ONLY after determination is made that payment is in the best interest of the Florida National Guard. FLARNG BUS Code NG5022: This position is “included” in the bargaining unit and eligible for labor organization representation. The current exclusive representative is The Association of Civilian Technicians, Chapter 87 and the President is Mr. Michael Ortmayer at email@example.com or (904) 573-2300 ext 1023. Military Grades: Warrant Officer/ Enlisted-CW2 and below GENERAL EXPERIENCE: Must have experience or training which demonstrates knowledge of equipment to be able to do routine jobs, simple preventative maintenance tasks, and is able to use common tools and equipment in the line of work. SPECIALIZED EXPERIENCE: WG-08 must have at least 12 months experience or training using common hand and power tools and a small variety of test and measurement devices to make mechanical repairs; experience removing, adjusting, replacing, cleaning, and installing a variety of parts, components, and accessories; experience which demonstrates a basic understanding of mechanical, electrical, and hydraulic theory applying to vehicles; and skill to replace, fit, install, and make adjustments; experience demonstrating an understanding of the makeup and operation of the various individual systems maintained and their interrelationships; experience reading and interpreting parts lists, manufactures repair manuals, diagrams, and electrical schematics. Education If you are using Education to qualify for this position: You must provide transcripts or other documentation to support your Educational claims. To receive credit for Education, you must provide documentation of proof that you meet the Education requirements for this position. Additional Information If you are a male applicant who was born after 12/31/1959 and are required to register under the Military Selective Service Act, the Defense Authorization Act of 1986 requires that you be registered or you are not eligible for appointment in this agency (https://www.sss.gov/RegVer/wfRegistration.aspx). If you are unable to apply online or need to fax a document you do not have in electronic form, view the following link for information regarding an Alternate Application.